check out the new remote control Jockey Wheel SmartBar Canegrowers rearview170 Cobb Grill Skid Row Recovery Gear
Members Login
Username 
 
Password 
    Remember Me  
Post Info TOPIC: Blocked Gas Regulator


Senior Member

Status: Offline
Posts: 274
Date:
Blocked Gas Regulator


Hi All,

Thought I'd share this with you. On a recent trip we had no gas in the van, therefore no fridge, no hot water, no stove, unhappy SWMBO. Tried the following:

1. Swap bottles 

2. Checked operation of change over valve.

Still no success. Determined regulator was blocked ( 10 years of faithful service). It was a Friday afternoon out of town and nothing close by over the weekend, so no chance of purchasing a replacement. Was suggested I remove the regulator and place in boiling water for 10 minutes. This melted out a substantial amount of oily, waxy matter.

Replaced regulator, stove lit faster than ever, same same fridge and hot water. Happy SWMBO! All still working, I now have a new regulator which I'll install before next trip.

The regulator sits just below the top of the bottles.

Now I'll slip on my flak jacket and wait for the incoming.

Cheers

Hurls

 

 



__________________

Mark & Chris

You are only young once but, you can be immature for ever.



Guru

Status: Offline
Posts: 1545
Date:

Will remember that if we need to get out of the same sticky situation



__________________

Jeff & Rae travelling in a motorhome



Guru

Status: Offline
Posts: 7640
Date:

Had similar with a bottle in Perth . May not be that particular bottle ? It was a waxy oil solution restricting flow . The bottle didnt seem to last long gas wise . Felt heavy . Suspect it was full of oil ?

__________________
Whats out there


Senior Member

Status: Offline
Posts: 417
Date:

We had similar problem last trip. Gas appeared to have run out during the night. When I took the bottle off it was still half full. When I switched back onto that bottle it was ok. I presume it was the regulator and that it cleared itself . Rod.

__________________

Rod.

Ah! The serenity

Tug - Mitsubishi Challenger, Van - Starcraft Outback Poptop..

 



Veteran Member

Status: Offline
Posts: 79
Date:

Thanks for the info Hurls. That'll go in my little black book if and when I need it.

__________________


Guru

Status: Offline
Posts: 1143
Date:

Had a hose from the bottle to the change over tap do the same thing. Would run fine on one bottle but not the other. New hose fixed the problem.

__________________

Greg O'Brien



Senior Member

Status: Offline
Posts: 211
Date:

Hurls, the regulator should be higher than the gas bottles. The gas hoses need to go uphill to the regulator so that any gunk in them will run back to the bottle.

Google for gas regulations and you will find this is correct.

All vans are not set up correctly by manufacturers, don't know how they pass inspection.

Barry

__________________
100 Series Turbo Cruiser & 21ft Lotus Trackvan


Guru

Status: Offline
Posts: 8493
Date:

BAZZA44 wrote:

Hurls, the regulator should be higher than the gas bottles. The gas hoses need to go uphill to the regulator so that any gunk in them will run back to the bottle.

Google for gas regulations and you will find this is correct.

All vans are not set up correctly by manufacturers, don't know how they pass inspection.

Barry


Bazza, Caravan manufacture is a self regulating industry in Australia - no inspections when new. 



__________________

Possum; AKA:- Ali El-Aziz Mohamed Gundawiathan

Sent from my imperial66 typewriter using carrier pigeon, message sticks and smoke signals.



Guru

Status: Offline
Posts: 7640
Date:

Just had a look at our regulator position . Its 100mm down from tap . Ahh its hard piped so moving it higher isnt easy . Even the experts dont get it right !! Notice it came good in warner weather . I guess less viscosity?

__________________
Whats out there


Guru

Status: Offline
Posts: 5378
Date:

I used the hot water trick, on a blocked regulator, but unfortunately for me, it did nor work

Yellow/brown/mustard coloured stuff came out of the pipe, (before the hot water trick)

I dismantled the (non serviceable) double regulator, with my hacksaw

What I found was that the rubber seats of the valves had expanded, and were therefore permanently closed

I made sure that when I got my new regulator, it had screws in it, so that I can dismantle it, if I get caught out again

Since then, I no longer have a gas fridge, so no gas for a few days, should not worry me any more
I carry a portable canister type stove, as a backup

__________________

Tony

It cost nothing to be polite



Guru

Status: Offline
Posts: 8493
Date:

Different suppliers also supply different gasses www.diffen.com/difference/CNG_vs_LPG this is one reason why some leave deposits and others don't.

__________________

Possum; AKA:- Ali El-Aziz Mohamed Gundawiathan

Sent from my imperial66 typewriter using carrier pigeon, message sticks and smoke signals.



Guru

Status: Offline
Posts: 1222
Date:

Possum that may hold in USA but in Australia LPG is propane and nothing else. Check out the Elgas web site for your own information. The gunk in the regulator is more likely due to breakdown of hoses or seals than out of the gas bottle.

Alan



__________________


Guru

Status: Offline
Posts: 8493
Date:

Brenda and Alan wrote:

Possum that may hold in USA but in Australia LPG is propane and nothing else.


 Alan Both LNG and LPG are used extensively in Australia - In some areas (Particularly remote areas) the gas truck refills both the bowsers (Car fuel) and the Refill bottle ( BBQ Bottles) from the same tanker. https://www.elgas.com.au/blog/486-comparison-lpg-natural-gas-propane-butane-methane-lng-cng 



__________________

Possum; AKA:- Ali El-Aziz Mohamed Gundawiathan

Sent from my imperial66 typewriter using carrier pigeon, message sticks and smoke signals.



Guru

Status: Offline
Posts: 7640
Date:

Hell painful when your gas regulator plugs up ! Warm beers . Angry Mrs ! Lol

__________________
Whats out there


Guru

Status: Offline
Posts: 1222
Date:

Possum what you say about the gas tanker filling both is because both are propane and neither are LNG. Propane and  LNG are not interchangeable in either gas appliances or vehicles as they require different pressures and/or different air/fuel ratios.

Alan



__________________


Guru

Status: Offline
Posts: 4586
Date:

A friend who worked in a senior position in the Qld Ampol refinery in Qld. for 20 years told me that the 'oily gunk' that collected in the regulator was from the additive that is used to give the gas a smell in case of leaks.

A LPG gas expert suggested that 7 years was the lifespan of a regulator.

 



__________________

See Ya ... Cupie




Senior Member

Status: Offline
Posts: 386
Date:

Had this with mine too.
fridge wouldn't start and stove was like it was on low at best.

Pulled the regulator and some sort of liquid came out.
Mine is atop my gas bottle, so is positioned correctly.
I did notice the old one had a small hole, which I assume is for a pressure release and this was facing upward.
When I installed the new one, I made sure this hole was pointed downward, as to not take on rain water etc .
Only 40 odd bucks I think and everything is back to normal.

cheers Brett

__________________
Page 1 of 1  sorted by
 
Quick Reply

Please log in to post quick replies.

Tweet this page Post to Digg Post to Del.icio.us
Purchase Grey Nomad bumper stickers Read our daily column, the Nomad News The Grey Nomad's Guidebook